Product ID:AEROSHELL FLUID 12
MSDS Date:07/18/1995
FSC:9150
NIIN:01-311-5640
MSDS Number: BYCPY

ROYAL LUBRICANTS CO INC

MERRY LANE
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411/800-424-9300

Info Phone: 201-887-7410

Cage: 6V632

ROYAL LUBRICANTS CO INC (REPLACED BY CAGE CODE 07950)

518 EAST HANOVER, NJ 07936 US

Telephone: 201-887-7410

Cage: 6V632

DI(2-ETHYLHEXYL) SEBACATE (SYNTHETIC ESTER)

CAS: 122-62-3

RTECS: VS1000000

Fraction By Weight: 93-97%

PETROLEUM SULFONATE (BARIUM DINONYLNAPHALENE SULFONATE)

CAS: 25619-56-1

Fraction By Weight: 2-4%

2,6-DI-TERT-BUTYL-P-CRESOL (BUTYLATED HYDROXY TOLUENE)

CAS: 128-37-0

RTECS: GO7875000

Fraction By Weight: 1.0-1.5%

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3; 9495

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRIT. SKIN:PROLON/REP CONTACT MAY
CAUSE VARIOUS SKIN DISORDERS (DERM,FOLLICULITIES,OIL ACNE).
INHAL:VAP (GENERATED @HIGH TEMPS ONLY)/OIL MIST MAY BE MILDLY IRRIT
TO NOSE/THROAT/RESP TRACT. INGEST :VOMIT,ASPIRATION (BREAHTING)OF
VOMITUSINTO LUNGS MUST BE AVOIDED AS EVEN SM QUANT MAY RESULT IN
ASPIRATION PNEUMONITIS
Explanation of Carcinogenicity:PER MSDS:THIS PRODUCT DOES NOT CONTAIN
ANY CARCINOGEN AS ID BY IARC/NTP/OSHA.
Effects of Overexposure:EYE IRRIT, SKIN DISORDERS (DERMATITIS,
FOLLICULITIES, OIL ACNE), IRRIT TO NOSE/THROAT/RESP TRACT.
VOMITING, ASPIRATION OF VOMITUS INTO LUNGS-ASPIRATION PNEUMONITIS
MAY BE EVIDENCED BY COUGHING, LABORE D BREATHING & CYANOSIS (BLUISH
SKIN), IN SEVERE CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS WHILE
HOLDING EYELIDS OPEN.GET MED ATTN. SKIN:REMOVE CONTAMIN
CLOTH/SHOES.WIPE EXCESS FROM SKIN.FLUSH W/WATER.FOLLOW BY WASHING
W/SOAP/WATER.IRRIT O CCURS GET MED ATTN. INHAL:REMOVE TO FRESH
AIR.BREATH DIFFI PROVIDE OXYGEN.GET MED ATTN. INGEST:DO NOT INDUCE
VOMIT.VOMIT OCCURS SPONT KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION
OF LIQ INTO LUNGS.(SUP)

Flash Point Method:COC
Flash Point:440F,227C
Extinguishing Media:USE WATER FOG,FOAM,DRY CHEM,CO2.DO NOT USE DIRECT
STREAM OF WATER.PROD WILL FLOAT;CAN BE REIGNITED ON SURFACE OF
WATER.
Fire Fighting Procedures:MATL NOT BURN UNLESS PREHEATED.DON'T ENTER
CONFINE FIRESPACE W/O FULL BUNKER GEAR(HELMET W/FCSHIELD/BUNK
COATS/GLOVES/RUBB BOOTS)INCLUDE +PRESS NIOSH SCBA.
Unusual Fire/Explosion Hazard:COOL FIRE EXPO CNTNRS W/WATER.

Spill Release Procedures:MAY BURN;NOT READILY IGN.USE CAUTIOUS
JUDGMENT.WEAR RESP/PROT CLOTH.SHUT OFF SOURCE
SAFELY.DIKE/CONTAIN.REMOVE W/VAC TRUCKS/PUMP TO STORAGE/SALVAGE
VESSELS.SOAKUP RESIDUE W/ABSORBENT(CLAY,SAND,SUITABL E MATL).FLUSH
AREA W/WATER TO REMOVE RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID CONTACT W/EYES.AVOID PROLONG/REP
CONTACT W/SKIN.STORE IN COOL,DRY PLACE W/ADEQUATE VENTI.KEEP AWAY
FRM OPN FLAM/HI TEMP.
Other Precautions:BE SAFE.READ OUR PRODUCT SAFETY INFO & PASS IT ON.

Respiratory Protection:USE NIOSH-APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE.IAW 29CFR1910.134.USE EITHER ATM-SUPPLYING
RESP OR AIR-PURIFYING RESP FOR ORG VAP/PARTICULATES.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:WEAR GLOVES.
Eye Protection:CHEM GOGGLES.
Other Protective Equipment:WEAR CLOTHING AS REQUIRED TO MIN CONTACT.
Work Hygienic Practices:DO NOT REUSE CLOTHING UNTIL CLEANED.WASH
W/SOAP/WATER BEF EAT/DRINK/SMOKE/TOILET FACILITIES.
Supplemental Safety and Health
1STAID:GET MED ATTN.PHYSICIAN:INGEST >2.0ML/KG & VOMIT HAS NOT
OCCURRED.EMESIS SHOULD BE INDUCED W/SUPERVISION.KEEP HEAD BELOW
HIPS TO PREVENT ASPIRATION.SYMPTOMS SUCH AS LOSS OF GAG
REFLEX/CONVULSION S/UNCONSC OCCUR BEF EMESIS GASTRIC LAVAGE USING
CUFFED ENDOTRACHEAL TUBE SHOULE BE CONSIDERED.

HCC:V6
Spec Gravity:0.92
Solubility in Water:NEGLIGBLE.
Appearance and Odor:LIGHT AMBER OIL, SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME.
Hazardous Decomposition Products:HI DEPENDENT ON COMBUST
CONDITIONS.COMPLEX MIX:AIRBORNE SOLID/LIQ/PART/GAS EVOLVE FRM PROD
PYRO/COMBUST.CO,UNID ORG CMPD

Waste Disposal Methods:DISPOSE OF AS HAZ WASTE D005 BASED ON BA
CONTENT.UNLESS EXTRACTION RESULTS SHOW >EPA LIMIT.PROD
CLASSIFIED:OIL EPA-CWA SEC311.SPILLS INTO/LEAD TO SURFACE WATERS
CAUSE SHEEN REPORT TO NAT RESP CNTR 800 -424-8802 SARA TITLE III.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.